Device and repair of Toyota RAV4 SUVs (Toyota RAV) - The radiator fan-//

Toyota PAB4-Toyota RAV4
1. Operation of the car
2. Maintenance
3. Engines
4. Cooling systems and conditioning
   General information
   Specifications
   Service and repair of the cooling system
      Thermostat
      Radiator fan
      Radiator and broad tank
      Water pump
      Sensor of the index of temperature of cooling liquid
      Radiator fan thermoswitch
      Heater fan electric motor
      Knot of management of systems of heating and air conditioning
      Heater radiator
   Check and service of the air conditioning system
5. Fuel system and system of production of the fulfilled gases
6. System of ignition
7. The control system and decrease in toxicity of the fulfilled gases
8. Coupling
9. Transmission
10. Driveshaft and shaft of the drive of driving wheels
11. Brake system
12. Suspension bracket
13. Steering and running gear
14. Body
15. Electric equipment
Schemes of electric equipment


Toyota RAV4>> Cooling systems and conditioning>> Service and repair of the cooling system>> Radiator fan
       PREVENTION
In operating time of the engine you do not bring a hand too close to the fan and do not stand in the plane of rotation of the fan

Switch off ignition and disconnect a wire of "weight" from the rechargeable battery.
Disconnect the electric socket from the radiator fan engine.
On release cars till 2001 the casing of the fan of the condenser of the air conditioning system fastens to a radiator one bolt from above and two in the basis. The casing of the main fan of a radiator fastens two bolts from above and two bolts in the basis.
On release cars since 2001 the casing of the fan of the condenser of the air conditioning system fastens to a radiator two bolts from above and two in the basis. The casing of the main fan of a radiator fastens two bolts from above and two clamps in the basis.
Tighten the parking brake and block back wheels an emphasis.
Lift a forward part of the car and establish on support. Remove an antisplash guard of a motor compartment.
On release cars till 2001 from below of the car turn out the lower bolts of fastening of a casing of the fan.

Fig. 4.6. Arrangement of the top bolts of fastening of a casing of the fan of a radiator


From above from a motor compartment turn out the top bolts of fastening of a casing of the fan and remove its (fig. 4.6) . On release cars since 2001 release a fan casing from clamps in the basis, having pulled it up.

Fig. 4.7. A reversing of the screw of fastening of the fan to an engine shaft


Holding fan blades from a provorachivaniye, turn out the screw of fastening of the fan to a shaft of the engine and remove its (fig. 4.7) . The fan of the condenser fastens to an engine shaft three screws.

Fig. 4.8. An arrangement of screws of fastening of the engine to a fan casing


Turn out screws of fastening of the engine to a casing of the fan and remove the engine (fig. 4.8) .
You make installation in the sequence, the return to removal.