Toyota PAB4-Toyota RAV4
1. Operation of the car
2. Maintenance
   General information on operational materials and adjusting data
   Volumes and frequency of maintenance
   Check of levels of operational liquids
   Survey of tires and check of pressure of air
   Replacement of engine oil and oil filter
   Check and replacement of rubber tapes of brushes of a screen wiper
   Check and adjustment of a free wheeling of a pedal of coupling
   Check, service and charging of the rechargeable battery
   Check, adjustment of a tension and replacement of a poliklinovy belt of the drive of hinged units
   Check and replacement of hoses in a motor compartment
   Shift of wheels
   Check of a condition of seat belts
   Check of a condition of brakes (each 24 000 km or 12 months)
   Replacement of the air filter
   Check of fuel system
   Check of level of oil in the mechanical transmission
   Check of level of oil in the transfer case of cars with the automatic transmission
   Check of a condition of a suspension bracket and steering
   Check of protective covers of power shafts
   Check of level of oil in reverse main gear on all-wheel drive cars
   Replacement of the filter of ventilation of salon on cars since 2001
   Replacement of brake fluid
   Replacement of the fuel filter on release cars till 2001
   Check and replacement of spark plugs
   Check and replacement of a cover and rotor of the distributor of ignition
   Replacement of cooling liquid and washing of the cooling system
      Discharge of cooling liquid
      Washing
      Filling
   Check of system of regeneration of vapors of fuel
   Check of system of production of the fulfilled gases
   Replacement of oil and the filter in the automatic transmission
   Replacement of oil in the mechanical transmission
   Replacement of oil in the transfer case on all-wheel drive cars with the automatic transmission
   Replacement of oil in reverse main gear on all-wheel drive cars
   Check and replacement of the valve and hose of ventilation of a case (PCV)
   Check and adjustment of gaps in the drive of Valves
3. Engines
4. Cooling systems and conditioning
5. Fuel system and system of production of the fulfilled gases
6. System of ignition
7. The control system and decrease in toxicity of the fulfilled gases
8. Coupling
9. Transmission
10. Driveshaft and shaft of the drive of driving wheels
11. Brake system
12. Suspension bracket
13. Steering and running gear
14. Body
15. Electric equipment
Schemes of electric equipment


Toyota RAV4>> Maintenance>> Replacement of cooling liquid and washing of the cooling system>> Washing
After discharge of cooling liquid remove the thermostat and establish into place a thermostat casing. It will allow to wash out the cooling system quicker.
Close a drain stopper of a radiator. Install the handle of management of a heater in the provision of the maximum heating in order that the radiator and hoses of a heater were also washed out.

Fig. 2.38. Washing of the cooling system: 1 – garden hose; 2 – top hose of a radiator; 3 – radiator


Disconnect the top hose of a radiator from a radiator, then insert a garden hose into a branch pipe of a radiator and wash out system a pure stream until the top hose of a radiator does not come out clear water (fig. 2.38) .
At serious pollution of a radiator remove a radiator and wash out it special means, observing the instruction for use.
Move a garden hose to a broad tank and wash out system a pure stream until the top hose of a radiator does not come out clear water.
Connect the top hose of a radiator to a radiator.